3 stage charging ac 115/230vac selected by switch built-in passive pfc function compliance to en61000-3-2 class a (opti on) protection: short circuit / reverse polarity / over voltage / over temper ature charger for lead-acid batteries 2 color led loading indicator low cost, high reliability fan on/off control(depends on charging current) 3 years warranty features : p:with passive pfc n:without passive pfc pb 360 12 specification pb-360 -12 model boost charge voltage float charge voltage output current (typ.) note 6 battery type voltage adjustable range recommended battery capacity(amp hours) note 5 output voltage range frequency range efficiency (typ.) power factor (typ.) input environment inrush current (typ.) leakage current over temperature safety standards harmonic current emi conduction & radiation safety & ems immunity emc (note 4) withstand voltage isolation resistance working temp. working humidity storage temp., humidity temp. coefficient vibration over voltage reverse polarity protection ac current (typ.) 14.4v 13.6v 24.3a open & sealed lead acid 80 ~ 240ah 13 ~ 14.7v 90 ~ 132vac / 180 ~ 264vac selected by switch 127 ~ 187vdc / 254 ~ 370vdc 47 ~ 63hz 85% >0.65 (with p type) at 230vac 7a/115vac 3.5a/230vac cold start 60a <3.5ma / 240vac 16 ~ 18v by internal fuse protection type : shut down o/p voltage, re-power on to recover protection type : automatically derate charge current until zero iec60335-2-29 cb approved by tuv(except for 48v), ul60950-1 approv ed compliance to en55022 (cispr22) class b compliance to en61000-3-2,-3 (only p type) compliance to en61000-4-2,3,4,5,6,8,11; env50204, en55024, li ght industry level, criteria a i/p-o/p:3kvac i/p-fg:1.5kvac o/p-fg:0.5kvac i/p-o/p, i/p-fg, o/p-fg:100m ohms / 500vdc / 25 / 70% rh -20 ~ +60 (refer to output load derating curve) 20 ~ 90% rh non-condensing -40 ~ +85 , 10 ~ 95% rh 0.05%/ (0 ~ 45 10 ~ 500hz, 2g 10min./1cycle, 60min. each along x, y, z axes mtbf 115.8khrs min. mil-hdbk-217f (25 ) 253*135*48.5mm(l*w*h) dimension others note packing 1.5kg; 6pcs/10kg/0.95cuft 1. all parameters not specially mentioned are measured at 230vac input, r ated load and 25 of ambient temperature. 2. ripple & noise are measured at 20mhz of bandwidth by using a 12" twisted pair- wire terminated with a 0.1uf & 47uf parallel capacitor. 3. tolerance : includes set up tolerance, line regulation and load regula tion. 4. the power supply is considered a component which will be installed into a fi nal equipment. the final equipment must be re-confirmed that it still me ets emc directives. 5. this is mean well's suggested range. please consult your battery manuf acturer for their suggestions about maximum charging current limit ation. 6. maximum charging current will be in the range of 90~110% rated output curr ent. p pb-360 series 360w single output battery charger function remote control (cn5) open: normal work short: stop charging (p type only) (except for 48v) 12:14.4v 24:28.8v 48:57.6v pb-360 -24 pb-360 -48 28.8v 57.6v 27.2v 54.4v 26 ~ 28.8v 52 ~ 58.6v 12.5a 6.25a 40 ~ 125ah 20 ~ 65ah 86% 87% 31 ~ 35v 59 ~ 64v short circuit o/p built in fuse (fs100) to protect short circuit condition, shut down o/ p voltage and can not re-power on file name:pb-360-spec 2010-04-12
mechanical specification charging curve file name:pb-360-spec 2010-04-12 case no.801a unit:mm state v boost 14.4v pb-360-12 28.8v pb-360-24 v flt 13.6v 27.2v charge current constant current stage 1 stage 2 stage 3 constant voltage start charge voltage v flt 100% red green led color boost v output load vs temperature 40 50 60 70 30 20 10 -20 load (%) 90 100 80 70 60 40 30 air flow direction 48.5 135 9.25 11 led -v 54 127 5.5 9 .75 on/off 230 inlet switch +v 235 253 12 pwm circuit detection o.l.p. emi filter rectifiers & passive p.f.c. power switching filter protection & reverse rectifiers polarity +v -v i/p fg control o.v.p. fan on/off control o.c.p. cn5 svr1 1 2 ambient temperature ( ) assignment pin1,2 open: normal work pin1,2 short: stop charging mating housing jst xhp jst sxh-001t-p0.6 or equivalent or equivalent terminal remote control(cn5) : jst b2b-xh or equivalent block diagram 360w single output battery charger pb-360 series fosc : 70khz 57.6v PB-360-48 54.4v
|
